Product ID:559 INDUSTRIAL ENAMEL
MSDS Date:01/03/1990
FSC:8010
NIIN:00F026617
MSDS Number: BQJQS

RUST-OLEUM CORP

11 HAWTHORN PKWY
VERNON HILLS, IL 60061-1583
US

Emergency Phone: 708-367-7700

Info Phone: 708-367-7700

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-55%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

LEAD CHROMATE, CR, CHROME GREEN, CHROME YELLOW (SUSPECTED

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 5-25%

OSHA PEL 0.5 MG/CUM PB

ACGIH TLV: 0.05 MG/CUM CR (A2)

7.7-9.8

RTECS: 9999999WG

RESIN

PIGMENT

ADDITIVES

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL. MAY AFFECT THE
BRAIN OR NERVOUS SYSTEM. NOSE & THROAT IRRITATION. EYES/SKIN:
IRRITATION. INGESTION: GASTROINTESTINAL IRRITATION, NAUSEA,
VOMITING & DIARRHEA. ASPIRATION HAZARD.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS OR COMA. PERMANENT BRAIN & NERVOUS SYSTEM, DAMAGE.
BIRTH DEFECTS, KIDNEY & NERVOUS SYSTEM DAMAGE & BLOOD EFFECTS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. EYES:
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM & QUIET.
ASPIRATIO N OF THIS MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:TCC
Flash Point:104F
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
FOAM)
Fire Fighting Procedures:USE SCBA. WATER SPRAY MAY BE INEFFECTIVE. USE
WATER TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD
UP/AUTOIGNITION/EXPLOSION. FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DON'T APPLY TO HOT SURFACES. COMBUSTIBLE
LIQUID.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON SPARKING TOOLS.

Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS II COMBUSTIBLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. EMPTY
CONTAINERS MAY BE HAZARDOUS. KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM ELECTRICAL EQUIPMENT.

Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
(TC23C) TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC
VAPORS DURING SPRAY APPLICATION. IN CONFINED AREAS USE A NIOSH
APPROVED SUPPLIED AIR RESPIRATORS OR HOODS (TC19C).
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST IN VOLUME & PATTERN TO
KEEP BELOW TLV.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY EYEWEAR
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:307-389F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:53-64

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, TEMPERATURES
>120F OR OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.